UltrabaseSystems Logo TourLinks Logo 1 866 921 7888


Yes. We have had innovative installers utilize our panels with adjustable pedestal systems, structural joist systems, or created a subfloor on which to rest the UBS panels. All of these procedures were implemented in an effort to elevate the panels and turf/athletic courts above any obstacles or obstructions on the existing roof.

Historically no, we have built hundreds of rooftop installations where the weight of the turf on top of the panels is all that is needed to keep the panels secured to the roof. The low profile aerodynamic design of the panels has, so far, allowed us to simply position the panels on the roof and install the turf. However, we do have methodologies of fastening the panels to a roof structure if there is a concern for high wind conditions. Consult our sales staff for this information.

In most cases, yes, the panels are engineered with a radius-ribbed bottom. However, in some cases, such as a rubber membrane, an additional stabilization fabric may be advised in order to ensure minimal indentation to the roof membrane.

UltraBaseSystems is an engineer’s dream product. Weighing less than two pounds per sq. ft., the structurally sound panels pose no load concerns for most roofing structures.

There are three major causes of a base failure: water, water, and water. If you have ground such as expansive clay soil, eliminating water from getting to the clay dramatically reduces the risk of base failure as well as reduces the amount of ground excavation and rock replacement.

Permeable allows water to flow through, and impermeable prevents water from passing into the ground.

We want this fabric to act like a support layer for the panels. By using a fabric like the ones we suggest, the panels stay resting on top of the properly prepared base which helps insure the horizontal drain slots stay clear. Without a stabilization fabric, the panels could sink in to the ground, choking horizontal flow.

We recognized early on that this product is much more than a weed barrier. The fabrics we selected and tested add to the structural stability of the UBS panels, hence helping stabilize the ground.

The fabric needs a high tensile strength and low elongation.

That is our specialty! We have been installing rooftop putting greens and green scape areas all over the world for over 10 years. These structurally superior yet lightweight panels make them an architect’s dream product.  When installing over a parking lot it is as easy as laying out the panels according to the installation guide, installing the turf and in an instant you have a beautiful recreation or sports area.